Product ID:D.E.H. (R) 52 EPOXY CURING AGENT
MSDS Date:11/07/1988
FSC:8040
NIIN:00-181-7188
MSDS Number: BDGJP

Emergency Phone: 517-636-4400

Info Phone: 517-636-1000

Cage: KO480

Telephone: 517-636-1000

Cage: KO480

DEH-52; AMINE-ADDUCT EPOXY HARDENER

CAS: 38294-69-8

LD50 LC50 Mixture:LD50(ORAL)=250-500 MG/KG (RAT)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYE:SEVERE INJURY &
IRRITATION,POSSIBLE LOSS OF VISION; SKIN:MODERATE BURN,POSSIBLE
SENSITIZER,10% AQUEOUS SOLUTION WAS NOT ABSORBED IN ACUTELY TOXIC
AMOUNTS; ING:UNDILUTED MATERIAL WOULD PROBABLY BUR N MUCOUS
MEMBRANES; INH:POSSIBLE ALLERGIC RESPIRATORY ASTHMA.
Effects of Overexposure:SEVERE BURNS,SENSITIZATION RESPONSE, LIVER AND
KIDNEY INJURY.
Medical Cond Aggravated by Exposure:EYES:MAY CAUSE IMPAIRMENT OF
VISION.STAIN FOR EVIDENCE OF CORNEAL INJURY.IF CORNEAL IS
BURNED,INSTALL ANTIBIOTIC STEROID PREPARATION FREQUENTLY.CONSULT
OPHTHALMOLOGIST.

First Aid:EYES:WASH WITH FLOWING WATER FOR 30MIN,PROMPT MEDICAL
ATTENTION;SKIN:FLUSH WITH PLENTY OF WATER AT LEAST 15MIN WHILE
REMOVING CONTAMINATED CLOTHING; ING:DO NOT INDUCE VOMITING,GIVE
LARGE AMOUNT OF WAT ER OR MILK IF AVAILABLE & TRANSPORT TO MEDICAL
FACILITY; INH:REMOVE TO FRESH AIR IF EFFECTS OCCUR.

Flash Point Method:PMCC
Flash Point:222F,106C
Autoignition Temp:Autoignition Temp Text:675 F
Lower Limits:2
Upper Limits:6.7
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NOT AVAILABLE

Spill Release Procedures:SOAK UP IN ABSORBENT MATERIAL. DO NOT WASH
INTO AREAS THAT WILL CAUSE POLLUTION.

Handling and Storage Precautions:AVOID BREATHING FUMES.

Respiratory Protection:APPROVED ORGANIC-TYPE VAPOR RESPIRATOR REQUIRED
IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:CONTROL OF VAPOR TO SUGGESTED GUIDE.
Protective Gloves:RUBBER
Eye Protection:GOGGLES/FACE SHIELD
Other Protective Equipment:RUBBER BOOTS,APRON.
Supplemental Safety and Health
NONE

HCC:B2
Spec Gravity:1.02
Solubility in Water:SLIGHTLY
Appearance and Odor:LIGHT YELLOW LIQUID, AMINE ODOR

Stability Indicator/Materials to Avoid:YES
ACID, CHLORINATED HYDROCARBONS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:NONE

Waste Disposal Methods:BURN IN ADEQUATE INCINERATOR OR BURY IN
LANDFILL,IN ACCORDANCE WITH LOCAL,STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.